Mr-Glass Impact Garage Doors Nationwide | Sightline Windows & Doors Boca Raton

Mr-Glass Impact Garage Doors: The Boca Raton Owner’s Guide

We stock and install Mr-Glass-compatible impact garage doors in Boca Raton, with typical installed prices running $2,800-$5,400 depending on opening size, wind-load rating, and whether the track hardware needs replacement. Most Mr-Glass impact garage doors we service are same-day measurable, and we carry common torsion springs, rollers, and impact-rated panels for the 3200 and 3400 series on our trucks. Most Boca Raton owners discover a problem when the door hangs crooked in the frame, groans through its travel, or fails to seal after a storm - the symptom that brings the call is rarely the only thing worn out.

Call (561) 200-8592

Which Mr-Glass Models This Applies To

Mr-Glass builds impact-rated garage doors under the 3200, 3400, and 3600 series designations. The 3200 is the single-layer aluminum impact door with a 2-inch rail and stile profile; the 3400 adds a thermal break and a heavier 3-inch frame. The 3600 is the insulated, wind-rated line rated to Miami-Dade HVHZ standards, and it is the one we see most often in Boca Raton’s newer construction east of Federal Highway. The model sticker is usually on the interior face of the bottom section, behind the rubber weatherseal, and it lists the design pressure rating - DP-50 or DP-60 - which tells us whether the door was built for the 170-mph or 200-mph zone.

We are an independent service provider; we are not affiliated with Mr-Glass. For parts, we source OEM when the series is still in production and use verified aftermarket equivalents when it is not. The 3200 series was discontinued in 2019, so those doors almost always run aftermarket track hardware and compatible springs. The 3400 and 3600 still carry OEM panels and hardware, though lead times from the factory run 3-4 weeks. We stock torsion springs sized for the 3200 and 3400 on our trucks, along with 2-inch and 3-inch roller sets, because those are what fail first in Boca Raton’s salt air.

Signs Your Mr-Glass Impact Garage Door Is Failing

• The door hangs crooked in the opening. This usually means a failed torsion spring or a seized roller on one side. On Mr-Glass doors, the 3200 series uses a lighter-gauge track that can twist if the spring goes unbalanced, so the crook is both symptom and cause of further damage.
• Grinding or groaning through the travel. The nylon rollers on early 3400 units degrade in UV faster than the steel bearings; once the nylon cracks, the steel rides directly on the aluminum track. We hear it before we see it, and by then the track is often scored.
• Visible daylight around the perimeter after the door closes. Impact-rated doors depend on perimeter seal compression to maintain their wind-load certification. A worn bottom rubber or sagging panel edge breaks that seal, and the door is no longer doing the job it was installed for.
• The opener strains or reverses mid-travel. Mr-Glass doors are heavier than standard residential doors - the 3600 series runs 180-220 pounds on a 16-foot opening - and a failing spring puts that load entirely on the opener. The motor overheats, the logic board faults, and now you have two problems.
• Panel dents or glazing cracks after a named storm. The impact-rated glass in a Mr-Glass door is laminated, so it may spider without falling out. But the dented aluminum stile behind it has lost structural integrity, and the next storm will find that weakness. We document this with photos, because insurance adjusters in Boca Raton have seen it before.

Before

After

Replacement Cost & What’s Included

The range depends on three things: whether we can reuse the existing track, whether the opener needs recalibration for the new door weight, and whether Boca Raton’s building department requires a permit for the work. We pull permits when they are required, pass inspection, and include that in the written scope. Every job carries our 365-Day Done Right Promise under the Haven Standard. The price we write is the price on the invoice - no change orders, no discoveries.

DIY or Call Us?

There is one thing a homeowner can safely check: whether the door is plugged in and whether the opener’s manual release is engaged. Everything else on a Mr-Glass impact garage door carries real hazard. Torsion springs are wound to 100+ foot-pounds of torque; a slip during adjustment or removal can break a hand or put a winding bar through a wall. The impact-rated panels are heavier than they look, and a 16-foot section of 3600-series door will bend its own frame if lifted unevenly. We have been called to jobs in Boca Raton where a well-intentioned owner made a $200 spring problem into a $1,800 door replacement.

We carry the right spring charts for Mr-Glass doors, the right winding bars, and the liability coverage. Measure it twice, write it down, then we can talk price. If you are unsure what series you have, text us a photo of the sticker and we will tell you before we drive out. Call (561) 200-8592 to schedule your free estimate.

FAQs